LENMISO Engine PCV Box Oil Separator Diaphragm with Spring Compatible with S40 V50 C70 Code p0174 p0171 Replace 30684381 30788494 31338684 31338685

Perfect fit for a 2016 Volvo XC60 Solved my issue

My son’s V50 was howling and stopped when I took off the oil filler cap. Pulling super strong suction through oil filler. Read that these diaphrams go bad and need replacing. Pulled air box to the side and popped off with stiff putty knife getting leverage on oil filter cap. Reused original cap but this replacement looked exact same. Lubed the lip of the PCV body with petroleum jelly and carefully positioned in place with the notch lined up and pressed down with 1/2 ratchet wrench levered off engine tab. It seated all the way round and totally fixed problem. Time will tell how long it lasts. I’m happy with purchase.

The part arrived on time, however, that is the only good thing. When the part arrived, I inspected the part which appeared to be identical at first glance. When I held the new PCV cover up to the original PCV cover, I noticed that the outer diameter of the New PCV cover was noticeably larger than the original. Inspecting the diaphragm in the new Cover, it appeared that it was slighter smaller, and less robust than the original diaphragm. I went for it anyway to install, since my original cover had a crack. Immediately as it tried to press the cover on, it was obvious that the new cover was not going to stay in place as it was slightly too large. Not sure what is going on with quality control, but this did not work on my T5 Volvo. YES IT DID look the same at first glance when I opened the package...this one is going back regrettably as it would have been a great deal if it fit!

Item fit my 2015 Volvo 2.5 liter turbo 5 cylinder engine. I could not however get the new cap to snap on to my old oil separator assembly. But I did get the new diaphragm to work with my old cap, although getting it back on was pretty hard. As you can see it in the picture I had to use a long board pry up against the intake manifold and push it down. Hope this helps others.

works fine, and fits like the original to Volvo s80 t5 2008 make. no more oil leaks or white smoke.

I was only able to use the diaphragm. The cover is a tad bit bigger where it will not secure snuggly in place. I was careful enough with the original cover to be able to reuse it. It's been about 5 months using this and is still holding up after about 5k miles. Hopefully it continues to.

My s40 was running really rought and engine pressure built up. this little cap fixed all those problems

Solved the problem on our 2012 s60 T5